畢業設計（論文）I礦井提升機電控系統原理設計摘要我國礦井提升機大多是采用交流異步電機拖動，其電氣控制系統采用轉子串、切電阻調速，由繼電器-接觸器構成邏輯控制裝置。本文以安全、可靠、高效、經濟為出發點，以可靠性原則為依據，對礦井交流提升機電控系統進行研究設計，由可編程控制器(PLC)代替繼電器-接觸器構成的邏輯控制裝置。其中簡單介紹了國內外礦井提升機發展概況，提升機機械結構、工作原理，分析了其技術經濟性。對于PLC的控制原理及應用做了一般性的介紹。詳述了提升機電控系統和調速原理，如：測速部分和保護部分。本文以TKD-NT單繩纏繞式礦井提升機為例，提出了研究設計方案，并且在實踐中成功實施。PLC電控系統實現了對提升過程的程序控制，精度高；實現了速度、電流以及矢量的數字交換等，對提升機進行閉環調節；實現行程、速度等重要參數及提升狀態的監視；實現無觸點控制，壽命長，可靠性大大提高，具有良好的控制監視系統；實現了顯示、記錄等有關數據的全部自動化。關鍵詞：礦井交流提升機，PLC，調速，電控技術研究畢業設計（論文）IITHEDESIGNOFELECTRICCONTROLSYSTEMBASEDONMINEELEVATORABSTRACTInChina,mineelevatorwhoseelectriccontrolsystemusesspeedregulationbymeansofstringingandslicingtherotorresistance,anditconstitutesthelogiccontroldevicebytherelayandcontactoradoptingthemeansofthedriveofACasynchronousmotorinmostcases.ThispaperwhichstudiesanddesignstheelectriccontrolsystemofACmineelevator,adoptingPLCwhichtakestheplaceofthelogiccontroldeviceconstitutedbytherelayandcontactortakesthesecurity,reliability,highefficiency,economyasastartingpoint,andtakesthereliabilityprincipleasthebasis.Thereinto,thispapergivesabriefintroductiononthedevelopmentofmineelevatorinhomeandabroad,itsframeworkandtheory,whiledoingsomeeconomicstudy.Then,itintroducesthetheoryandapplicationofPLCsimply.Ontheside,itgoesintoparticularsaboutelectriccontrolsystem,forexample,speedmeasurementandsafeguard.ThispapersetsTKD-NTelevatorforanexample,proposestheresearchanddesignplanwhichputsinpracticesuccessfully.TheelectriccontrolsystembasedonPLChascarriedouttheprocedurecontrolofhoistprocessandhighaccuracy,closed-cyclecontrolofmineelevatorthroughspeed,electriccurrentaswellasdigitalswitchingofvectorandsoon,themonitorofimportantparameterssuchasthedistanceoftravel,speed,thestateofhoist.Inaddition,thesystemalsohascarriedoutcontactlesscontrol,longlife-span,reliabilitygreatlyimproved,goodcontrolsupervisorysystemandcompletelyautomationofrelevantdatasdemonstration,recordingandsoon.KEYWORDS:ACmineelevator,PLC,speedregulation,electriccontroltechnologyresearch畢業設計（論文）III目錄前言.1第1章國內外礦井提升機發展概述.21.1錯誤!未找到引用源。國外礦井提升機現狀.21.2我國礦井提升機電氣控制系統的現狀.2第2章提升機機械結構及工作原理.42.1機械結構.42.2工作原理.5第3章串電阻調速系統.73.1串電阻調速系統原理.73.2串電阻調速程序.8第4章提升機電控系統構成.144.1引言.144.2主回路.154.3測速回路.164.4安全回路.164.5控制回路.184.5.1信號回路.184.5.2電機正反轉回路.184.5.3制動回路.194.5.4轉子電阻控制回路.194