生產車間環境清潔消毒規程okXX化妝品有限公司生產車間環境清潔消毒規程制定人：審核人：批準人：文件編碼：SMP09021頁碼：1/3頒發部門：品質部生效日期：文件編寫/修訂歷史：本文件為第一次修訂，第一版目的：定期對生產環境(包括空氣、設備、輔助工具、工作臺面、人手)進行清潔消毒，確保整個生產環境的衛生受控，減少對產品的可能污染和交叉污染。適用范圍：本工作規程僅適用于對本公司生產場所進行環境衛生的消毒作業。職責：1.車間崗位操作員負責對設備和環境進行清潔消毒。2.車間主管及組長執行培訓并監督本規程的實施。3.品控部負責監督此規程的執行。內容：1.術語及定義生產車間：指本公司完成化妝品稱料、調配乳化、灌封、包裝整個生產過程的區域。2.清潔用具：地拖、毛巾、紙巾。3.清潔劑：自來水、純化水，卸甲水。4.消毒劑：75%的酒精、500ppm次氯酸鈉溶液。5.具體要求6.生產設備6.1攪拌機6.1.1清潔方法：出料完畢，立刻用生產用去離子水對攪拌機進行清洗，清洗完畢后，用裝75%酒精的噴壺對攪拌機的內表面全方位噴灑75%酒精進行消毒，消毒結束后自然晾干并保持容器的密閉。開工投料前，先用裝75%酒精的噴壺對攪拌機的內表面全方位噴灑75%酒精。停留1分鐘后，通過水槍用去離子水對攪拌機內表面進行沖洗至無酒精氣味。每周對設備管道表面進行清潔，擦掉表面的灰塵，擰緊管道的螺絲，需要潤滑的部位檢查加潤滑油。6.2充填機6.2.1清潔頻次：下班或轉換產品時。6.2.2清潔程序：拆下灌裝管道，用卸甲水循環清洗管道，第一道先用比較濃的卸甲水沖洗干凈管道內的剩余原料；更換干凈的卸甲水再一次沖洗，直到?jīng)_洗干凈為止；然后用壓縮空氣吹干管道，注意金粉和其他產品的管道分開使用；用95%的酒精擦拭設備表面，如有殘留的半成品，用卸甲水擦洗干凈。6.3各類膠桶、膠勺、膠鏟6.3.1消毒頻次：每次使用前后。外燈消毒時需注意眼部保護，避免直接照射眼睛。Aftereachuse,soaktheutensilsin80℃hotwateror95%alcoholtoremoveanyresidualmaterialsonthesurface,thendisinfectthemwith75%alcoholandletthemairdryinaclosedspace.Forhandhygiene,followsteps6and7ofthe"PersonnelEntryintoCleanAreaFlowchart"tocleanandrinsehands.Then,spraybothhandswithadisinfectantsolutionof75%alcoholfromahanddisinfectantdispenserandallowittoevaporatenaturallybeforecontinuingwork.Forcolleagueswhoareallergictoalcohol,useaspraybottlefilledwitha500ppmsodiumhypochloritesolutiontosprayhandsanddrythemwithatowelortissue.Whencleaningtheworkbench,useadampclothorsolventtowipethesurfacecleanandfreeofdust,stains,andresidues.Donotplaceanyitemsrelatedtothecurrentbatchofproductionontheworkbench.Usetoolsanddisinfectantsindesignatedbasketswithclearlabelsinsteadofplacingthemontheworkbench.Disinfecttheworkbenchevery4hoursbysprayingwith75%alcoholandwipingitcleanwithadisinfectantcloth.Disinfectthespaceonceaweekbyclosingalldoorsandwindows,turningonanozonegeneratorwithaproductioncapacityof25g/hfor1hour,andkeepingitonfor8hours.Then,ventilatethespaceforatleast4hoursbeforepersonnelcanenter.Ifthereisacleanareawithultravioletlamps,setthelampstoautomaticallydisinfectthespaceafterpersonnelhaveleft.Turnonthelampsfornolessthan30minutestoensurethatallareasareexposedtoultravioletlight,andwaitfor30minutesafterturningoffthelampsb