1、 SYD-387深色石油產品硫含量試驗器使 用 說 明 書GLMGS2002年06月06日一、產品簡介One, product introductionSYD-387深色石油產品硫含量試驗器（管式爐法） 是根據國家標準GB/T387深色石油產品硫含量測定法（管式爐法）規定的要求設計制造的，適用于測定深色石油產品中的硫含量。本儀器通過裝有試樣的石英舟，在定流量的凈化的高溫?zé)峥諝鈿饬髦羞M(jìn)行完全燃燒，用過氧化氫和硫酸的溶液，將生成的亞硫酸酐和硫酸酐充分吸收，生成的硫酸用氫氧化鈉標準溶液進行滴定。SYD-387dark sulfur in petroleum products ( tubular ov

2、en method ) is based on the national standard GB / T387" dark petroleum products - Determination of sulphur content ( tubular oven method" ) in accordance with the requirements of the design and manufacture, applied in the determination of sulfur content in petroleum products dark. The app

3、aratus through a sample of quartz boat, in the constant flow of high temperature hot air purification for complete combustion, hydrogen peroxide and sulfuric acid solution, will generate the sulphurous acid anhydride and sulfuric anhydride fully absorbed, generation of sulfuric acid with sodium hydr

4、oxide standard solution titration.二、技術指標Two, technical indicators使用電源： AC 220V±10% 50Hz； In use of power: AC220V + 10% 50Hz;加熱爐型式與數量：水平型并列雙管管式電阻爐； Of heating furnace type and quantity : horizontal type double-tube parallel tube type resistance furnace;電阻爐爐膛直徑：22mm； Of resistance furnace: <22

5、mm in diameter;電阻爐加熱功率：1400W×2； Of resistance furnace heating power:1400W x 2;電阻爐最高使用溫度：950； Of resistance furnace: maximum use temperature of950 DEG c;電阻爐移動距離：不小于135mm； Of resistance furnace moving distance: not less than 135mm;供氣流量：不小于150L/h； Of gas flow: not less than 150L / h;時間設定最大值：99分59秒

6、（100min）。Set the maximum of time:99minutes and 59 seconds (100min ).三、產品特點Three, product characteristics本儀器主要由管式爐爐溫控制儀空氣流量指示裝置、顯示裝置等部分組成。Of the instrument is mainly composed of tubular furnace, a furnace temperature control system, air flow indicating device, display device and other components.采用單片

7、機組成智能控制系統，檢測時間、爐體移動、到時報警等功能實現自動控制。The intelligent control system of single chip microcomputer, detection time, furnace body movement, and alarm functions to realize the automatic control.按要求設置好爐體移動方式后，儀器按照試驗程序的要求，爐體會自動移動、自動停止和自動返回初始工作狀態。According to the requirements set up of furnace body moves, app

8、aratus according to the test program requirements, furnace, automatic stop automatic mobile experience and automatic return to original state.本儀器設計有水平型并列雙管管式電阻爐，可同時對2個試樣進行試驗，試驗效率高，試驗結果準確可靠。In the apparatus design level of double tube type resistance furnace, simultaneously on the2samples are tested,

9、 the test efficiency is high, the test results are accurate and reliable.設有置供氣裝置和外接氣源接口，可以使用部氣源，也可以使用外部氣源Of which is internally provided with a gas supply device and the external air source interface, you can use the internal source, can also use external source四、儀器成套In four, complete sets of equipm

10、ent管式爐硫含量試驗器 Tube type furnace of sulfur in電源線（自制） Of power line ( homemade)無閥洗氣瓶，250mL Of valveless gas washing bottle,250mL有閥洗氣瓶，250mL U have valve gas washing bottle,250mL接受瓶，250mL In the receiving flask,250mL石英彎管 Of quartz tubes石英管 Of quartz tube石英舟 Of the quartz boat玻璃彎管（5） Glass pipe ( <5).電熱絲（0.5×5.5×340） Of electric wire ( <0.5 x <5.5x 340)電熱絲（0.5×5.5×220）