1、碳酸飲料消費流程及設備09829007崔寅.Carbonated beverage production processes and equipment 09808914 劉懿.引見指含有二氧化碳的軟飲料，通常由水、甜味劑、酸味劑、香精香料、色素、二氧化碳?xì)饧捌渌o料組成，俗稱汽水.IntroductionRefers to carbon dioxide in soft drink，Tt is known as soda，usually by water, sweeteners, sour agents, flavors and fragrances, pigments, carbon di

2、oxide gas and other raw material composition, .一、消費工藝流程飲用水水處置 混合冷卻碳酸化灌裝密封檢驗廢品飲料 糖 漿 調配 容器清洗 檢驗將調味糖漿與水預先按照一定比例泵入汽水混合機內，進展定量混合后再冷卻，然后將該混合物碳酸化后再裝入容器。又稱為預調式灌裝法、廢品灌裝法或前混合premix法.Fist. The production processDrinking waterWater Treatment MixCollingCarbonatedFillingSealTestFinished Drinks SyrupDeploy Contai

3、ner-Clean-TestFlavored syrup and water will be in accordance with a certain percentage of pre-soda mixer pump, doing the quantitative mixing before cooling,and then put the mixture into the container after carbonation. Also known as the preset filling method, pre-finished filling method or premix me

4、thod.二、水處置參與藥劑4%、7%、1%的氫氧化鈣，硫酸亞鐵，次氯酸鈣 生活用水原水沉清池砂濾罐碳濾罐精濾處置水洗瓶用水 離子交換安裝 軟化水 飲料用水 .Second.Water TreamentJoining the pharmacy 4%, 7%, 1% calcium hydroxide, ferrous sulfate, calcium hypochlorite Domestic waterRaw waterShen-ChiSand filter tankCarbon filter tankFiltrationWater treatmentWashing water Ion ex

5、change unit Softened water Drink water .三、二氧化碳凈化工藝流程 二氧化碳罐車液體儲罐壓力13.5-22Kg/cm2氣化器水溫40-70調壓閥9Kg/cm2水洗器氧化器2-3%高錳酸鉀溶液中和器5-10%碳酸鈉溶液水氣分別器吸附器精濾器緩沖罐流量計消費線壓力0.7-0.8Mpa .Third, carbon dioxide cleaning processCarbon Dioxide Tank Liquid storage tank (pressure 13.5-22Kg/cm2) Vaporizer (water temperature 40-70 )

6、 regulators (9Kg/cm2) water washing oxidation reactor device (2-3% potassium permanganate solution ) And in devices (5-10% sodium carbonate solution) Moisture separator absorber gas separator Fine filterBuffer tank Flowmeter Production Line (pressure 0.7-0.8Mpa).四、糖液的制備前糖漿配制工藝流程 活性炭 硅藻土1：1助濾劑 砂糖 溶糖缸

7、6080盤式過濾器板式交換器精濾器板式交換器儲罐后糖漿待用.Fourth .Preparation of sugar.四、糖液的制備 飲料用水 主劑配糖缸后糖漿待用后糖漿儲罐攪拌靜置脫氣 飲料待用糖漿.五，混合.六、灌裝.六、灌裝.噴碼.七 、暖瓶.八、吹干.九、包裝.消毒主要有以下幾種消費線的CIP消毒方法：三步清洗: 1)處置水沖洗,將設備內剩余物沖走 2)用1.0左右的NaOH溶液循環15-20分鐘, 3)處置水沖洗,將設備內剩余堿液沖走三步熱清洗 1)處置水沖洗,將設備內剩余物沖走 2)用60-70度NaOH溶液循環30分鐘, 3)處置水沖洗,將設備內剩余堿液沖干凈三步熱清洗消毒 1)處置水沖洗,將設備內剩余物沖走 2)用85度NaOH溶液循環15分鐘,濃度為1.0左右 3)處置水沖洗,將設備內剩余堿液全部沖干凈.三步熱消毒 1)處置水沖洗,將設備內剩余物沖走 2)用85度熱水循環15分鐘 3)處置水沖洗,將設備內剩余熱水沖走,冷卻設備,降至室溫五步清洗消毒 1)處置水沖洗,將設備內剩余物沖走 2)用溫度為65-75度,濃度為1.0左右的NaOH溶液循環15-20分鐘, 3)處置水沖洗,將設備內剩余堿液沖走 4)用85度的熱水循環10-15分鐘,或用鹵水(50